Abstract

This Letter demonstrates the application of polymer optical fibers (POFs) damaged by the fiber fuse effect to curvature sensing and dynamic angular monitoring. The curvature sensing performance using the fused-POF is compared to POF without the fuse effect. Both POFs are submitted to angles of up to 90 deg in flexion/extension cycles with angular velocities ranging from 0.48 rad/s to 5.61 rad/s. The fused POF is found to show higher performance with respect to sensitivity, correlation coefficient with linear regression, and hysteresis. For instance, at the angular velocity of 0.48 rad/s, the fused POF shows $>3$ times higher sensitivity and significantly lower hysteresis than those of the non-fused POF. In addition, the fused POFs have lower cross-sensitivity and hysteresis variations on the tests with different angular velocities. These results indicate that the fused POFs are potential candidates to develop curvature sensors with various advantages over non-fused POFs, for applications such as gait analysis and wearable robotics.

© 2018 Optical Society of America

Dynamic mechanical analysis on fused polymer optical fibers: towards sensor applications

Arnaldo Leal-Junior, Anselmo Frizera, Maria José Pontes, Paulo Antunes, Nélia Alberto, Maria Fátima Domingues, Heeyoung Lee, Ryo Ishikawa, Yosuke Mizuno, Kentaro Nakamura, Paulo André, and Carlos Marques
Opt. Lett. 43(8) 1754-1757 (2018)

Design considerations, analysis, and application of a low-cost, fully portable, wearable polymer optical fiber curvature sensor

Arnaldo G. Leal-Junior, Anselmo Frizera, Leticia M. Avellar, and Maria José Pontes
Appl. Opt. 57(24) 6927-6936 (2018)

Strain, temperature, moisture, and transverse force sensing using fused polymer optical fibers

Arnaldo Leal-Junior, Anselmo Frizera, Heeyoung Lee, Yosuke Mizuno, Kentaro Nakamura, Tiago Paixão, Cátia Leitão, M. Fátima Domingues, Nélia Alberto, Paulo Antunes, Paulo André, Carlos Marques, and Maria José Pontes
Opt. Express 26(10) 12939-12947 (2018)

Characterization of a new polymer optical fiber with enhanced sensing capabilities using a Bragg grating

Arnaldo Leal-Junior, Antreas Theodosiou, Anselmo Frizera-Neto, Maria José Pontes, Ehud Shafir, Oleg Palchik, Nadav Tal, Shlomi Zilberman, Garry Berkovic, Paulo Antunes, Paulo André, Kyriacos Kalli, and Carlos Marques
Opt. Lett. 43(19) 4799-4802 (2018)

Polymer-optical-fiber-based sensor system for simultaneous measurement of angle and temperature

Arnaldo Leal-Junior, Anselmo Frizera, Carlos Marques, and Maria José Pontes
Appl. Opt. 57(7) 1717-1723 (2018)